Replacing Floor In Camping Trailer

Lay new floor covering according the manufacturer s instructions.

Replacing floor in camping trailer.

A wooden floor is pretty easy to replace just get the boards and fit them into the trailer although it s not always so straightforward. When you lay the new plywood replacement piece in the hole it will be supported by the cleat and you simply run screws through the new plywood into the cleat. Rigid floor coverings typically linoleum and tiles in rvs must usually be broken off in small pieces using a pry bar or broad bladed screwdriver and will need to be replaced. I m working on a 2004 rockwood trailer floor.

You will probably have to use a flathead screwdriver to get the flooring up. We understand in today s economy that everyone is trying to do more with less and replacing your entire floor may not be in the cards or not necessary. Using 2 1 2 inch drywall screws we drove screws down through the existing flooring into the cleat spacing the screws close to 3 inches on center. The area is in the kitchen in front of the lower cabinets.

Then rip up the old flooring replace with new flooring and replacing everthing that was inside again. Install a carpet threshold bar over the join between your new floor covering and the rv travel trailer s original floor coverings. Sketch out your rv and make a diagram of the inside furniture walls etc. Replacing the floor involves taking out everything on the inside cabinets counters beds seating dinette furnace fridge bathroom fixtures well everything.

Drill a countersunk pilot hole every 6 inches and secure the ply panel in place using treated exterior decking screws. The damaged area is approximately 6 long x 4 wide. Slot the board ends into the channels one at a time. Clear furniture and start removing the current floor.

You don t want to replace the living room floor only to. However in your own trailer you ll want to take this step to its logical conclusion and ensure you know the full extent of the damage before you go about replacing the floor. I ve torn up the vinyl to find an area of wood rot caused by water.